ISSN : 1301-5680
e-ISSN : 2149-8156
Turkish Journal of Thoracic and Cardiovascular Surgery     
Pektoralis pedikül flep kullanılarak trakeal nekrozun başarılı tedavisi: Olgu sunumu
Negar Eftekhar1, Anahita Borjian2, Shahab Rafieian1, Mohammad Amin Borjian2, Mehdi Abbasi Sahebi1
1Department of Thoracic Surgery, Tehran University of Medical Science, Tehran, Iran
2Tehran University of Medical Science, Cancer Institute, Tehran, Iran
DOI : 10.5606/tgkdc.dergisi.2020.18144


Thyroidectomy is considered an overall low-risk procedure. However, severe life-threatening complications, including tracheal necrosis may occur postoperatively. A 45-year-old male patient was referred to our clinic for papillary thyroid carcinoma surgery. The patient had mediastinitis signs and symptoms seven days after total thyroidectomy. Subsequent imaging demonstrated air leak and with mediastinitis as the primary diagnosis, and the patient underwent reoperation. During the operation, four necrotic tracheal rings were found to be the source of air leak. Due to tissue inflammation and infection, neither primary repair with tracheal resection and anastomosis, nor strap muscle plugging procedure were feasible. Therefore, a pedicle flap derived from the right pectoralis major muscle was transferred to the necrotic trachea. The patient"s clinical condition improved after the operation and subsequent bronchoscopies confirmed healing of trachea. During six-month follow-up, no complications were observed. In conclusion, the technique discussed in the current report shows promising outcomes for reconstructing large tracheal defects in inflammatory conditions where primary repair techniques are not suitable.

Thyroidectomy is considered an overall low-risk procedure. However, the incidence of lifethreatening postoperative complications, including tracheal necrosis, is not unlikely.[1] A number of predisposing factors have been proposed such as high pressure of the endotracheal tube cuff, prolonged intubation period, altered blood perfusion to the injury site, and infections.[2] For the treatment of these complications, both conservative and surgical procedures are used.[2,3]

In the current report, we present a novel management technique for tracheal necrosis, using the pedicle pectoralis flap which was performed successfully in a patient with a papillary thyroid carcinoma (PTC).

Case Presentation

A 45-year-old male patient was referred to our surgery clinic with a chief complaint of an asymmetrical neck mass for the past two years. His past medical history was non-specific for any comorbidities and his most recent documented thyroid function test results were within normal ranges. His family history was also unremarkable. Ultrasonography showed diffuse thyroid enlargement with bilateral lymphadenopathy at the levels of II, V, VI, and VII. Fine needle aspiration biopsy result was reported as a PTC. Surgery was decided. A written informed consent was obtained from the patient. He, then, underwent total thyroidectomy, bilateral neck and mediastinal lymph node dissection through the collar incision and partial sternotomy. The pathology report also confirmed the diagnosis of a PTC with the involvement of upper mediastinal and central lymph nodes (Levels VI and VII) and bilateral involvement of lateral lymph nodes (Levels II, IV, and V on both sides) (T2N1bM0 - Stage II).

Six days after surgery, oral temperature increased to 37.9ºC; however, his respiratory condition was stable and his arterial blood gas (ABG) indices were normal. On Day 7, oral temperature reached 38.8ºC and he developed signs of neck pneumoderma. Immediately, a thoracic computed tomography scan was performed which indicated signs of air leak. The patient's clinical condition became worsened and he developed moderate respiratory distress (respiratory rate: 29/min, on room air O2 s aturation: 7 8%). A nother A BG s ample w as taken from the patient which showed a partial pressure of oxygen in arterial blood (PaO2) of 44 mmHg and partial pressure of carbon dioxide (PCO2) of 29 mmHg (on room air). The patient was initiated supplementary O2 with a reservoir mask (flow rate: 8 to 10 L/min). Then, his O2 saturation increased to 92% and, with close cardiopulmonary monitoring, he was transferred to the operation room emergently. Due to improvement of O2 saturation and to avoid further tracheal damage, the patient was not intubated in the ward. In the operating room, another ABG sample was taken from the patient which showed an O2 saturation o f 9 2%, PaO2 of 62 mmHg, and PCO2 of 31 mmHg. The patient was, then, intubated and underwent reoperation under mechanical ventilation.

During the operation, the source of the air leak was found to be the necrosis of lateral aspects of four tracheal rings. Due to the tissue inflammation and infection, neither primary repair with tracheal resection and anastomosis, nor strap muscle plugging were feasible (Figure 1). Therefore, a pedicle flap derived from the right pectoralis major muscle (with maximal care to preserve the vascular pedicle) was transferred to the necrotic trachea and anterior mediastinum (Figures 2-4). A No. 7 tracheostomy tube (Portex®, cuffed, N. 7, internal diameter: 7 mm, outer diameter: 9 mm, length: 62 mm) (Smiths Medical ASD Inc., Minneapolis, MN, USA) was inserted through an intact ring (Figure 5). The stoma was, then, sealed using the right pectoralis major muscle. A percutaneous endoscopic gastrostomy tube was also inserted.

Figure 1: Necrotic lateral aspects of tracheal rings and mediastinitis in the patient with respiratory distress, emphysema, and fever.

Figure 2: Transferring pectoralis pedicle flap to the site of tracheal necrosis to cover defect (Part 1).

Figure 3: Transferring pectoralis pedicle flap to the site of tracheal necrosis to cover defect (Part 2).

Figure 4: Transferring pectoralis pedicle flap to the site of tracheal necrosis to cover defect (Part 3).

Figure 5: Inserting tracheal tube through intact rings after flap transfer.

Two days later, bronchoscopy showed tissue repair and alleviating inflammation. Three days after the reoperation, there was a significant reduction in pneumoderma and tissue inflammation with improved clinical condition. Another bronchoscopy on Day 20 demonstrated granulation tissue formation with no further necrosis, air leak, or inflammation. Therefore, tracheostomy tube was removed (Figure 6). The patient received radioactive iodine treatment with I131 (150 mCi) as the adjuvant treatment. The patient was discharged one day after tracheostomy removal (Day 21). During a six-month follow-up period, he demonstrated no signs and symptoms indicating complications such as a stricture or fistula.

Figure 6: Bronchoscopy on Day 20 after tracheal repair showing signs of tissue healing and no further necrosis.


To date, a number of studies have focused on using muscular flaps in tracheal repair, among which is a report by Meyer et al.[4] who discussed the outcomes of 13 large intrathoracic airway defects closure using extra-thoracic muscle flaps (latissimus dorsi and serratus anterior). The authors reported that follow-up bronchoscopies showed epithelialization of the repair site with no signs of stenosis, dehiscence, or fistulas.[4] In a case report, Lin et al.[5] also presented the reconstruction of a membranous tracheal defect using an intercostal muscle flap. In their case, follow-up bronchoscopy showed favorable results of the aforementioned technique with minor complications. Similarly, Naamee et al.[3] reported promising outcomes after using pedicle intercostal muscle flaps for tracheal reconstruction on a large necrotic site, where a pulmonary patch was not feasible. In addition, Escott and Pooching[6] reported a successful technique using the myovascular flap and tissue-bonding agent in a case of posterior tracheal perforation after thyroidectomy. In another report, Golger et al.[2] presented a case of tracheal necrosis after thyroidectomy, where three necrotic tracheal rings were excised and anastomosis was not possible due to large defects. Instead, a T-tube was inserted and tissue repair was performed around it.

A report of total tracheal resection in a patient with adenoid cystic carcinoma, and subsequent tracheal reconstruction using the radial forearm free flap was first presented by Beldholm et al.[7] The authors discussed the favorable function of the reconstructed trachea in their patient, emphasizing the potential of this reconstruction technique, when primary anastomosis was not possible. In another report by Thomet et al.,[8] two cases of successful tracheal reconstruction using the free radial forearm flaps harvested from the rib cartilage (a modified technique) were discussed. The authors reported satisfactory results in both cases without any complications including stenosis, fistula formation, prolonged stenting, or necrosis at 26-month and 44-month follow-up visits. He et al.[9] also reported a similar technique to our study, in which they repaired tracheal defect after resection of an inflammatory myofibroblastic tumor in the thoracic trachea. The authors concluded that using a myocutaneous flap was a safe reconstructive technique for large tracheal defects. In our patient, due to delayed diagnosis, severe inflammation and infection in the necrotic site and fragile tissues, tracheal resection and anastomosis or strap muscle plugging were not feasible. Therefore, a pedicle pectoralis major flap was used to cover the necrotic rings. The main difference between our study and the case reported by He et al.[9] is that the aforementioned report is a reconstruction of thoracic trachea after tumor resection in a sterile environment with minimal inflammation and necrosis. However, in our case, reconstruction was performed in the cervical trachea in an inflammatory environment with fragile tissues.

In conclusion, the technique discussed in the current report shows promising outcomes for reconstructing large tracheal defects in inflammatory conditions where primary repair techniques are not suitable with favorable tissue repair and infection, inflammation, and air leak control. To the best of our knowledge, this is the first case in which a pectoralis flap was used in a such setting. Since tracheal necrosis may be accompanied by other conditions which potentially makes primary repair unfavorable, we believe that this technique may be useful in similar scenarios. However, further studies are needed to examine the efficacy and long-term outcomes of this technique.

We would like to acknowledge the technical support and collaboration of Cancer Institute of Tehran Imam Khomeini Hospital Complex, during the course of this study.

Declaration of conflicting interests
The authors declared no conflicts of interest with respect to the authorship and/or publication of this article.

The authors received no financial support for the research and/or authorship of this article.


1) Conzo G, Stanzione F, Della Pietra C, Palazzo A, Candilio G, Fiorelli A, et al. Tracheal necrosis, oesophageal fistula: unusual complications of thyroidectomy. Report of two case and literature review. Ann Ital Chir 2012;83:259-64.

2) Golger A, Rice LL, Jackson BS, Young JE. Tracheal necrosis after thyroidectomy. Can J Surg 2002;45:463-4.

3) Naamee A, Galvaing G, Chadeyras JB, Farhat M, Page JP, Bony-Collangettes E, et al. Tracheoplasty With Use of an Intercostal Muscle Flap for Caustic Necrosis. Ann Thorac Surg 2015;100:e103-5.

4) Meyer AJ, Krueger T, Lepori D, Dusmet M, Aubert JD, Pasche P, et al. Closure of large intrathoracic airway defects using extrathoracic muscle flaps. Ann Thorac Surg. 2004;77:397-404.

5) Lin J, Rajdev P, Mulligan MS. Reconstruction of a complex tracheal injury using an intercostal muscle flap. Ann Thorac Surg 2014;97:679-81.

6) Escott AB, Pochin RS. Repair of a posterior perforation of the trachea following thyroidectomy with a muscle transposition flap. Ear Nose Throat J 2016;95:E14-7.

7) Beldholm BR, Wilson MK, Gallagher RM, Caminer D, King MJ, Glanville A. Reconstruction of the trachea with a tubed radial forearm free flap. J Thorac Cardiovasc Surg 2003;126:545-50.

8) Thomet C, Modarressi A, Rüegg EM, Dulguerov P, Pittet- Cuénod B. Long-segment tracheal reconstruction with free radial forearm flap reinforced by rib cartilage. Ann Plast Surg 2018;80:525-8.

9) He J, Xu X, Chen M, Li S, Yin W, Wang S, et al. Novel method to repair tracheal defect by pectoralis major myocutaneous flap. Ann Thorac Surg 2009;88:288-91.

Keywords : Pektoralis kası, tiroidektomi, trakea
Viewed : 2474
Downloaded : 809